Use of Marble Powder and Tile Powder as Cementitious Materials in Concrete

  • N. Bheel Department of Civil Technology, Hyderabad College of Science and Technology, Pakistan
  • K. A. Kalhoro Department of Civil Technology, Hyderabad College of Science and Technology, Pakistan
  • T. A. Memon Department of Civil Technology, Hyderabad College of Science and Technology, Pakistan
  • Z. U. Z. Lashari Department of Civil Technology, Hyderabad College of Science and Technology, Pakistan
  • M. A. Soomro Department of Civil Technology, Hyderabad College of Science and Technology, Pakistan
  • U. A. Memon Department of Civil Technology, Hyderabad College of Science and Technology, Pakistan
Keywords: marble powder, tile powder, utilizing waste products, reducing environmental pollution, increasing strength of concrete

Abstract

The use of agricultural and industrial waste products as raw materials in the construction industry is investigated extensively. These products are inexpensive and help in environmental sustainability, as environmental pollution is thus reduced. This study focused in investigating the properties of fresh, physical and hardened concrete blended with marble (MP) and tile powder (TP) of several proportions, such as 0%, 5% (2.5%MP + 2.5%TP), 10% (5%MP + 5%TP), 15% (7.5%MP + 7.5%TP), and 20% (10%MP + 10%TP) by weight. A total of 60 concrete cylinders were cast with 0.45 water/cement ratio, 1:1.96:2.14 mix ratio, and were cured for 7 and 28 days. These cylinders were used for checking the compressive and splitting tensile strength of concrete. The experimental results showed that compressive and splitting tensile strengths were increased by 8.90% and 8.30% respectively for the 2.5%MP + 2.5%TP sample after 28 days.

Downloads

Download data is not yet available.

References

N. Gautam, V. Krishna, A. Srivastava, “Sustainability in the concrete construction”, International Journal of Environmental Research and Development, Vol. 4, No. 1, pp. 81-90, 2014

A. Manimaran, M. Somasundaram, P. T. Ravichandran, “Experimental study on partial replacement of coarse aggregate by bamboo and fine aggregate by quarry dust in concrete”, International Journal of Civil Engineering and Technology, Vol. 8, No. 8, pp. 1019-1027, 2017

K. Krizova, P. Novosad, T. Jarolím, “Production of self compacting concrete SCC with Portland and blended cement CEM I, CEM II with fly ash and limestone admixtures”, Advanced Materials Research, Vol. 1124, pp. 45-50, 2015

S. A. Mangi, M. H. W. Ibrahim, N. Jamaluddin, M. F. Arshad, F. A. Memon, R. P. Jaya, S. Shahidan, “A review on potential use of coal bottom ash as a supplementary cementing material in sustainable concrete construction”, International Journal of Integrated Engineering, Vol. 10, No. 9, pp. 28-36, 2018

S. A. Abdullah Anwar, S. Mohd, A. Husain, S. A. Ahmad, “Replacement of cement by marble dust and ceramic waste in concrete for sustainable development”, International Journal of Innovative Science, Engineering and Technology, Vol. 2, No. 6, pp. 496-503, 2015

A. D. Sakalkale, G. D. Dhawale, R. S. Kedar, “Experimental study on use of waste marble dust in concrete”, International Journal of Engineering Research and Applications, Vol. 4, No. 10, pp. 44-50, 2014

R. Siddique, “Performance characteristics of high-volume class F fly ash concrete”, Cement and Concrete Research, Vol. 34, No. 3, pp. 487-493, 2004

V. M. Shelke, P. Pawde, R. Shrivastava, “Effect of marble powder with and without silica fume on mechanical properties of concrete”, IOSR Journal of Mechanical and Civil Engineering, Vol. 1, No. 1, pp. 40-45, 2012

H. Y. Aruntas, M. Guru, M. Dayi, I. Tekin, “Utilization of waste marble dust as an additive in cement production”, Materials & Design, Vol. 31, No. 8, pp. 4039-4042, 2010

A. Talah, F. Kharchi, R. Chaid, “Influence of marble powder on high performance concrete behavior”, Procedia Engineering, Vol. 114, pp. 685-690, 2015

N. Bheel, R. A. Abbasi, S. Sohu, S. A. Abbasi, A. W Abro, Z. H. Shaikh, “Effect of tile powder used as a cementitious material on the mechanical properties of concrete”, Engineering, Technology & Applied Science Research, Vol. 9, No. 5, pp. 4596-4599, 2019

N. Bheel, S. L. Meghwar, S. Sohu, A. R. Khoso, A. Kumar, Z. H. Shaikh, “Experimental study on recycled concrete aggregates with rice husk ash as partial cement replacement”, Civil Engineering Journal, Vol. 4, No. 10, pp.2305-2314, 2018

N. Bheel, S. L. Meghwar, S. A. Abbasi, L. C. Marwari, J. A. Mugeri, R. A. Abbasi, “Effect of rice husk ash and water-cement ratio on strength of concrete”, Civil Engineering Journal, Vol. 4, No. 10, pp. 2373-2382, 2018

Z. H. Shaikh, A. Kumar, M. A., Kerio, N. Bheel, A. A. Dayo, A. W. Abro, “Investigation on selected properties of concrete blended with maize cob ash”, ICEC 10th International Civil Engineering Conference, Karachi, Pakistan, March 13-14, 2019

S. A. Mangi, M. H. W. Ibrahim, N. Jamaluddin, M. F. Arshad, S. A. Memon, S. Shahidan, “Effects of grinding process on the properties of the coal bottom ash and cement paste”, Journal of Engineering and Technological Sciences, Vol. 51, No. 1, pp. 1-13, 2019

S. A. Mangi, M. H. W. Ibrahim, N. Jamaluddin, M. F. Arshad, P. J. Ramadhansyah, “Effects of ground coal bottom ash on the properties of concrete”, Journal of Engineering Science and Technology, Vol. 14, No. 1, pp. 338-350, 2019

V. R. Rao, D. S. R. Murty, M. A. K. Reddy, “Study on strength and behavior of conventionally reinforced short concrete columns with cement from industrial wastes under uniaxial bending”, International Journal of Civil Engineering and Technology, Vol. 7, No. 6, pp. 408-417, 2016

N. Bheel, A. W. Abro, I. A. Shar, A. A. Dayo, S. Shaikh, Z. H. Shaikh, “Use of rice husk ash as cementitious material in concrete”, Engineering, Technology & Applied Science Research, Vol. 9, No. 3, pp. 4209-4212, 2019

A. A. Dayo, A. Kumar, A. Raja, N. Bheel, Z. H. Shaikh, “Use of sugarcane bagasse ash as a fine aggregate in cement concrete”, Engineering Science and Technology International Research Journal, Vol. 3, No. 3, pp. 8-11, 2019

M. Barbuta, A. A. Serbanoiu, C. Cadere, C. M. Helepciuc, “Effects of marble waste on properties of polymer concrete”, Advanced Engineering Forum, Vol. 21, pp. 213-218, 2017

O. M. Omar, G. D. Abd Elhameed, M. A. Sherif, H. A. Mohamadien, “Influence of limestone waste as partial replacement material for sand and marble powder in concrete properties”, HBRC Journal, Vol. 8, No. 3, pp. 193-203, 2012

K. Dharani, N. Dhanaseker, “Experimental study on partial replacement of cement by marble powder & quarry dust”, International Journal for Research in Applied Science and Engineering Technology, Vol. 5, No. 10, pp. 1766-1770, 2017

A. A. Aliabdo, A. E. M. A. Elmoaty, E. M. Auda, “Re-use of waste marble dust in the production of cement and concrete”, Construction and Building Materials, Vol. 50, pp. 28-41, 2014

M. M. Ali, S. M. Hashmi, “An experimental investigation on strengths characteristics of concrete with the partial replacement of cement by marble powder dust and sand by stone dust”, International Journal for Scientific Research & Development, Vol. 2, No. 7, pp. 360-368, 2014

N. Sharma, R. Kumar, “Use of waste marble powder as partial replacement in cement sand mix”, International Journal of Engineering Research & Technology, Vol. 4, No. 5, pp. 501-504, 2015

Z. Prosek, K. Seps, J. Topic, “The effect of micronized waste marble powder as partial replacement for cement on resulting mechanical properties of cement pastes”, Advanced Materials Research, Vol. 1144, pp. 54-58, 2017

F. Pacheco-Torgal, S. Jalali, “Compressive strength and durability properties of ceramic wastes based concrete”, Materials and Structures, Vol. 44, No. 1, pp. 155-167, 2011

E. Fatima, A. Jhamb, R. Kumar, “Ceramic dust as construction material in rigid pavement”, American Journal of Civil Engineering and Architecture, Vol. 1, No. 5, pp. 112-116, 2013

V. S. N. V. L. Ganesh, N. C. Rao, E. V. R. Rao, “Partial replacement of cement with tile powder in M40 grade concrete”, International Journal of Innovations in Engineering Research and Technology, Vol. 5, No. 7, pp. 34-39, 2018

M. Sekar, “Partial replacement of coarse aggregate by waste ceramic tile in concrete”, International Journal for Research in Applied Science and Engineering Technology, Vol. 5, No. 3, pp. 473-479, 2017

S. Aswin, V. Mohanalakshmi, A. A. Rajesh, “Effects of ceramic tile powder on properties of concrete and Paver block”, Global Research and Development Journal for Engineering, Vol. 3, No. 4, pp. 84–87, 2018

H. S. Arel, “Re-use of waste marble in producing green concrete”, International Journal of Civil and Environmental Engineering, Vol. 10, No. 11, pp. 1377-1386, 2016

B. P. R. V. S. Priyatham, D. V. S. K. Chaitanya, B. Dash, “Experimental study on partial replacement of cement with marble powder and fine aggregate with quarry dust”, International Journal of Civil Engineering and Technology, Vol. 8, No. 6, pp.774-781, 2017

Metrics

Abstract Views: 98
PDF Downloads: 55

Metrics Information
Bookmark and Share